leaching flotation of copper

leaching flotation of copper

Leaching characteristics of copper flotation waste before ...

2006-12-1 · Leaching of Cu, Zn and Pb metal ions decreased as the level of SiO 2 increased. While Cu release from vitrified copper flotation waste was 5.2 mg/L, Cu release from vitrified copper flotation waste with addition of 20% and 60% SiO 2 was 1.3 and 0.3 mg/L, respectively. Similar results were determined for Zn and Pb release.

Read More

RECOVERY OF COPPER FROM OXIDE COPPER ORE BY

2014-12-24 · RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION AND LEACHING Kiraz, Emirhan M.S., Department of Mining Engineering Supervisor: Prof. Dr. Mustafa Ümit Atalay December 2014, 65 pages The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) leaching.

Read More

COPPER EXTRACTION BY BIO-LEACHING OF FLOTATION

2019-6-10 · Figure 1 Bio-leaching mechanisms: Direct and indirect ones (Smith & Misra, 1991) EXPERIMENTAL Flotation Concentrate The sulphide concentrate used in the experiments is the result of the copper sulphide flotation process from a primary ore (underground mining). The copper sulphide flotation concentrate under

Read More

Ferric leaching of copper slag flotation tailings ...

2009-1-1 · Copper can be recovered from the slags by froth flotation after cooling, crushing, and grinding. The obtained Cu-concentrate is sent to the pyrometallurgical process. If grinding is not fine enough for efficient flotation, copper is lost in tailings. In this paper, the ferric leaching of slag flotation tailings is studied.

Read More

LEACHING OF FLOTATION TAILINGS - TMT 2018

2018-1-4 · leaching process has no significant effect on degree of copper. Optimum leaching time is 4 h. Based on the results, shown in Figure 4, the optimal ratio of S:L for the copper leaching process from flotation tailings is 1:2.5. The highest degree of copper leaching of 56% was achieved in the following

Read More

Studies of leaching of copper ores and flotation wastes ...

2014-2-16 · The study involved two types of ore (KGHM1 and PBK), copper concentrate and flotation waste four types (Gilów, Waste 3, Gilów 2, Waste 1). Using ICP–MS analysis content of individual elements (ppm) in the tested samples was determined. The process of digestion and leaching of uranium ores and flotation wastes was carried out by two methods.

Read More

Recovery of Copper from Flotation Tailings by Leaching ...

The best leaching conditions are stirring speed of 30 m/min, H2SO4 concentration of 150 Kg/t ore, leaching time of 30 minutes. Under the best conditions, the acid leaching test presented that the production of per ton copper consumes sulfuric acid of 17.31 t, and Cu leaching rate is 84.70%.

Read More

Recovery of Copper from Ammoniacal Leachates by Ion

2021-4-27 · Copper and zinc extraction by ammoniacal leaching from microwave-roasted Cu-Zn-Pb sulfidic tailings followed by recovery of copper and zinc by ion flotation and precipitation. Introduction Tailings are mixtures of fine-grained unwanted fractions after mineral beneficiation of ores at a mining site that are considered as a waste [ 1 , 2 ].

Read More

Copper Leaching Method - Metallurgist &

2019-4-19 · Copper Leaching Practices. For centuries small amounts of copper have been recovered from acid mine-drainage waters. In recent years, the

Read More

Leaching of Copper Sulphides - SAIMM

2016-6-8 · Leaching of Copper Sulphides Marc Nicolle,1 Marko Lampi,2 Kari Valkama, 2 and Janne Karonen 1 Outotec (RSA) (Pty) Ltd, Johannesburg, South Africa. ... The leach residue is subjected to flotation to recover pyrite and elemental sulphur which is subsequently fed to an oxidising autoclave. Within the autoclave, the elemental sulphur and ...

Read More

Leaching characteristics and mechanism of copper

2015-5-7 · The copper deposit in Yangla zone of China is large, and its recovery is low only using flotation process. Therefore, the copper in the flotation tailings is leached by sulfuric acid can improve copper recovery. The factors affecting leaching process and the leaching mechanism were investigated in this study. Copper is leached at a rate of 53.8% when initial H2SO4

Read More

Leaching behavior and immobilization of copper flotation ...

2011-2-22 · In this study, the leaching characteristics of copper flotation waste have been evaluated by the Toxicity Characteristic Leaching Procedure (TCLP), Synthetic Precipitation Leaching Procedure (SPLP), Extraction Procedure (EP Tox), and Field Leach Test (FLT) tests methods. The adsorption capacities and adsorption efficiencies were determined.

Read More

Studies of leaching of copper ores and flotation wastes ...

2014-2-16 · The study involved two types of ore (KGHM1 and PBK), copper concentrate and flotation waste four types (Gilów, Waste 3, Gilów 2, Waste 1). Using ICP–MS analysis content of individual elements (ppm) in the tested samples was determined. The process of digestion and leaching of uranium ores and flotation wastes was carried out by two methods.

Read More

LEACHING OF FLOTATION TAILINGS - TMT 2018

2018-1-4 · leaching process has no significant effect on degree of copper. Optimum leaching time is 4 h. Based on the results, shown in Figure 4, the optimal ratio of S:L for the copper leaching process from flotation tailings is 1:2.5. The highest degree of copper leaching of 56% was achieved in the following

Read More

Recovery of Copper from Flotation Tailings by Leaching ...

The best leaching conditions are stirring speed of 30 m/min, H2SO4 concentration of 150 Kg/t ore, leaching time of 30 minutes. Under the best conditions, the acid leaching test presented that the production of per ton copper consumes sulfuric acid of 17.31 t, and Cu leaching rate is 84.70%.

Read More

Recovery of Copper from Ammoniacal Leachates by Ion

2021-4-27 · Copper and zinc extraction by ammoniacal leaching from microwave-roasted Cu-Zn-Pb sulfidic tailings followed by recovery of copper and zinc by ion flotation and precipitation. Introduction Tailings are mixtures of fine-grained unwanted fractions after mineral beneficiation of ores at a mining site that are considered as a waste [ 1 , 2 ].

Read More

Agitated Copper Leaching & Cementation Process

2016-4-14 · Copper Agitated Leaching and cementation process of copper problem: The treatment of copper ores, both oxides and sulfides by means of flotation, hydrometallurgy or other processes has been well established for

Read More

Recovery Cu from a Copper Oxide Ore by Flotation and

Mexican copper ore is a mixed ore containing mainly copper oxide and some copper sulfide that responds well to flotation. The joint techniques of flotation and leaching were studied.

Read More

(PDF) Leaching of Gangue in Technological Flotation ...

2010-6-6 · Acidic leaching, preceding the flotation process, plays a beneficial role of efficient chemical grinding for liberation of copper sulphide minerals finely disseminated in

Read More

Leaching of Copper Sulphides - SAIMM

2016-6-8 · Leaching of Copper Sulphides Marc Nicolle,1 Marko Lampi,2 Kari Valkama, 2 and Janne Karonen 1 Outotec (RSA) (Pty) Ltd, Johannesburg, South Africa. ... The leach residue is subjected to flotation to recover pyrite and elemental sulphur which is subsequently fed to an oxidising autoclave. Within the autoclave, the elemental sulphur and ...

Read More

COPPER EXTRACTION BY BIO-LEACHING OF FLOTATION

2019-6-10 · Figure 1 Bio-leaching mechanisms: Direct and indirect ones (Smith & Misra, 1991) EXPERIMENTAL Flotation Concentrate The sulphide concentrate used in the experiments is the result of the copper sulphide flotation process from a primary ore (underground mining). The copper sulphide flotation concentrate under

Read More

Leaching of a copper flotation concentrate with

摘要 The leaching behavior of a copper flotation concentrate was investigated using ammonium persulfate(APS) in an autoclave system. The decomposition products of APS, active oxygen, and acidic medium were used to extract metals from the concentrate.

Read More

Leaching kinetics of copper flotation tailings in aqueous ...

2012-4-9 · The main copper minerals contained in the flotation tailings are chrysocolla, malachite, and cuprite, with the copper grade of 1.12%. Effects of lixiviant concentration, solid-to-liquid ratio, stirring speed, and reaction temperature on copper leaching ratios at

Read More

Recovery of Copper from Flotation Tailings by Leaching ...

The best leaching conditions are stirring speed of 30 m/min, H2SO4 concentration of 150 Kg/t ore, leaching time of 30 minutes. Under the best conditions, the acid leaching test presented that the production of per ton copper consumes sulfuric acid of 17.31 t, and Cu leaching rate is 84.70%.

Read More

PERCOLATION BIOLEACHING OF COPPER SULPHIDES

2019-6-10 · Bio-leaching Tests Monitoring the Process Parameters The process parameters such as pH, being constantly adjusted for the range of 1.8 to 2.2, redox potential were monitored, and Fe2+ and Fe3+ ionic species concentrations and copper extraction were frequently evaluated. The leaching tests were kept under stirring at 150 rpm, at 30ºC for 62 days.

Read More

Hydrometallurgical Production of Copper From Flotation ...

Hydrometallurgical Production of Copper From Flotation Concentrates By J. R. Cobble, C. Jordan, and D. A. Rice United States Department of the Interior Bureau of Mines . ... leaching process can be summarized by the chemical reaction shown below.

Read More

GALVANIC INTERACTIONS OF SULFIDE MINERALS IN

2010-9-13 · copper leaching. Electrochemical nature of sulfides flotation (Chanturija and Vigdergauz, 2009) and leaching along with electrocatalytic properties of pyrite has already been described (Majima and Peters, 1968; Nowak et al., 1984; Holmes and Crundwell, 1995) and used for leaching of copper sulphidic concentrates in the

Read More

Leaching of Copper Sulphides - SAIMM

2016-6-8 · Leaching of Copper Sulphides Marc Nicolle,1 Marko Lampi,2 Kari Valkama, 2 and Janne Karonen 1 Outotec (RSA) (Pty) Ltd, Johannesburg, South Africa. ... The leach residue is subjected to flotation to recover pyrite and elemental sulphur which is subsequently fed to an oxidising autoclave. Within the autoclave, the elemental sulphur and ...

Read More

Investigation of the optimal technology for copper ...

2020-7-22 · This work aimed to investigate optimal leaching technology for copper extraction from old flotation tailings of the Copper Mine Bor. The leaching degree of copper after leaching with sulphuric acid at 80 °C was 50%, the maximal leaching degree was achieved after 30 minutes. Then, old flotation tailings were leached with adapted moderately thermophilic acidophilic

Read More

REPROCESSING OF THE OLD FLOTATION TAILINGS

2018-12-31 · The average copper removal degree in the leaching stage was 70%. After re-flotation, the total copper removal degree reached 83 to 85%. Sulphur removal degree reached 77%. Sulphur concentration in the treated tailings was reduced almost 5 times compared to the inlet concen-tration. An equivalent amount of iron was also reduced through the ...

Read More